Mercedes C-Class

W203 since 2000 of release

Repair and car operation



Mercedes-Benz
+ Mercedes-Benz Cars of a class C (W-203)
+ Operation manual
+ Routine maintenance
+ Engine
+ cooling and heating Systems
+ Power supply system and release
- Engine electric equipment
   + ignition and engine management System
   + System of preheat of the diesel engine
   + Diagnostics of systems of electronic control and diagnostic equipment
   - Charge and start systems
      The storage battery - the main data and acquisition of the new battery
      Check and charging of the storage battery
      Replacement of the storage battery
      Storage of the storage battery
      Charging system - general information and security measures
      Check of system of a charging
      Removal and generator installation
      Removal and installation of a regulator of tension. Replacement of brushes
      System of start of the engine - the general information and precautionary measures
      Removal and starter installation
      Removal and installation of the traction relay of a starter
      Check of system of start of the engine
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment







Removal and starter installation

The electric motor called by a starter is necessary for start of an internal combustion engine. That the engine of the car earned, it not less than 300 rpm are necessary to untwist it till the speed. It is possible for reaching, if the starter reliably works and the storage battery is charged.

As start of the engine needs big electricity consumption, at carrying out maintenance it is necessary to pay attention to reliable connection of cables. The contacts having a rust, it is necessary to smooth out and grease with konsistentny greasing.

Removal

 PERFORMANCE ORDER

1. Disconnect a negative cable (-) the storage battery at vyklyuchyonny ignition. Previously it is necessary to remove a box of the filter of air of salon.

Before a detachment of a cable find out a protective code of a radio receiver if that is available, address to the Section Replacement of the storage battery.

Do not connect the auxiliary power supply.

2. Lift and establish on supports a forward part of the car.

 Operation of lifting and car installation on supports is connected with danger! Therefore before carrying out operation familiarize with Poddomkrachivaniye's Section and Introduction towage to the management.

3. Uncover the bottoms, address to the Section Removal and installation of a cover of an impellent compartment from the bottom.
4. Engine 112: Remove system of production of the fulfilled gases.

5. Unscrew nuts (1) and disconnect electric wires from a starter.

6. Turn out 2 screws (2) on a starter.
7. Take aside a cable plait with the holder and take out a starter down from an impellent compartment.